| Sign In to gain access to subscriptions and/or personal tools. |
DOI: 10.1080/01926230500416302
Acute Pulmonary Toxicity Caused by Exposure to Colloidal Silica: Particle Size Dependent Pathological Changes in MiceDepartment of Veterinary Pathology, Tottori University, Minami 4-101, Koyama, Tottori-shi, Tottori 680-0945, Japan Correspondence: Address correspondence to: Akinori Shimada, Department of Veterinary Pathology, Tottori University, Minami 4-101, Koyama, Tottori-shi, Tottori 680-0945, Japan; e-mail:aki{at}muses.tottori-u.ac.jp
To compare the pulmonary toxicity between ultrafine colloidal silica particles (UFCSs) and fine colloidal silica particles (FCSs), mice were intratracheally instilled with 3 mg of 14 nm UFCSs and 230 nm FCSs and pathologically examined from 30 minutes to 24 hour postexposure. Histopathologically, lungs exposed to both sizes of particles showed bronchiolar degeneration and necrosis, neutrophilic inflammation in alveoli with alveolar type II cell swelling and particle-laden alveolar macrophage accumulation. UFCSs, however, induced extensive alveolar hemorrhage compared to FCSs from 30 minutes onwards. UFCSs also caused more severe bronchiolar epithelial cell necrosis and neutrophil influx in alveoli than FCSs at 12 and 24 hours postexposure. Laminin positive immunolabellings in basement membranes of bronchioles and alveoli of UFCSs treated animals was weaker than those of FCSs-treated animals in all observation times. Electron microscopy demonstrated UFCSs and FCSs on bronchiolar and alveolar wall surface as well as in the cytoplasm of alveolar epithelial cells, alveolar macrophages and neutrophils. Type I alveolar epithelial cell erosion with basement membrane damage in UFCSs treated animals was more severe than those in FCSs-treated animals. At 12 and 24 hours postexposure, bronchiolar epithelial cells in UFCSs-treated animals showed more intense vacuolation and necrosis compared to FCSs-treated animals. These findings suggest that UFCSs have greater ability to induce lung inflammation and tissue damages than FCSs.
Key Words: Acute pulmonary toxicity • colloidal silica • electron microscopy • fine • intratracheal instillation • mice • ultrafine
Amorphous silica is a naturally occurring or synthetically produced oxide of silicon characterized by the absence of pronounced crystalline structure, and which has no sharp peaks in its X-ray diffraction pattern (Van Niekerk et al., 2002). There are several types of amorphous silica including fumed silica, colloidal silica, diatomaceous earth and precipitated silica. A number of studies have reviewed the adverse effects of amorphous silica; this silica has potential to induce transient pulmonary inflammation but changes may regress during the recovery period compared to persistent pulmonary inflammation by crystalline silica (Pratt, 1983; Reuzel et al., 1991; Warheit et al., 1995). In humans, an epidemiologic investigation in occupational exposure to amorphous silica generally showed no evidence of silicotic effect and any potential for carcinogenicity (McLaughlin et al., 1997). However, in an occupational setting study, a significant decrease in lung function was observed after amorphous silica exposure (Choudat et al., 1990). Colloidal silica is one of synthetically amorphous silica that consists of stable dispersion spherical silica particles. The particle sizes are usually of the order from 10 micrometers to less than 10 nanometers. Recently, the colloidal silica became widely used in many industries and available for various applications such as fiber, sizing, diazo paper manufactures, cellophane film, ceramics, grass fiber, paints, batteries, food, and polishing. Toxicological characteristics of the colloidal silica are characterized fairly well as being less toxic than crystalline forms in experimental animals. Kelly and Lee (1990) reported that inhalation of 50 or 150 mg/m3 Ludox colloidal silica for 4 weeks produced dose-related pulmonary effects characterized by accumulation of silica-dust-laden alveolar macrophages, neutrophilic infiltration, and type II epithelial cell hyperplasia. The severity and incidence of pulmonary lesions were reduced after a 3-month recovery period, most particle-laden alveolar macrophages (AMs) had disappeared and the remaining AMs were aggregated and sharply demarcated, although small number of silicotic lesions were described and lymph nodes were enlarged. They concluded the no-observable-effect level (NOEL) was 10 mg/m3. Traditional inhalation toxicity study clearly demonstrated that Ludox colloidal silica is far less active in producing pulmonary effects when compared to Minusil crystalline silica (Warheit et al., 1995). Moreover most of the biochemical parameters such as lactate dehydrogenase, total protein and N-acetyl glucosaminidase (NAG) returned to control values after a 3-month recovery period. In a subchronic inhalation study of Ludox colloidal silica, Lee and Kelly (1993) demonstrated the evidence of the transmigration of particle-laden alveolar macrophage from the alveoli to the interstitium and the tracheo-bronchial lymph node (TBLN) via interstitial lymphatics. In addition, subsequent intra-alveolar silicotic granuloma formations in the interstitium were also observed in the study. Ultrafine particles (UFP) are commonly defined as particles with diameter less than 100 nm that are ubiquitous in urban ambient air as both singlet and aggregated particles. Ultrafine particulates represent a substantial component in terms of particle numbers in PM10 (particulate matter <10 µm aerodynamic diameter), although they represent a relatively small fraction of the total mass. Currently, the potentially harmful role of ultrafine particle receives considerable attention as a possible explanation for the epidemiological associations of increase in PM10 with health effects (Donaldson et al., 2001). Many toxicological studies makes it clear that ultrafine particles of various types can cause lung inflammatory responses, epithelial cell hyperplasia, inhibit phagocytosis, increased chemokine expression, lung fibrosis, increased oxidant-generating abilities, and lung tumors (Zhang et al., 1998a, 1998b; Brown et al., 2000; Donaldson and MacNee, 2001; Warheit, 2004). Ultrafine particles are also implicated as of the adverse effects of particulate air pollution on the cardiovascular system by the induction of airway inflammation, leukocyte expression, increased endothelial adhesion molecule in blood, change in blood coagulability and alteration of cardiac electrical activity (Frampton, 2001; Nemmar et al., 2002; Donaldson and Stone, 2003; Gilmour et al., 2004). It has been demonstrated that ultrafine particles cause greater inflammatory responses and the development of particle-mediated lung diseases than the fine particles per given mass (Li et al., 1999; Nemmar et al., 2003). Data of the pulmonary pathological effects of amorphous colloidal silica in experimental animals are limited and precise mechanisms of the induced pathological changes are not clearly understood. To date, there is no pathological report on comparative pulmonary toxicity of fine and ultrafine colloidal silica. The purpose of this study is to describe acute pulmonary pathological effects caused by intratracheal exposure to amorphous colloidal silica and compare the size effects in light and electron microscopy.
Experimental Animal Female ICR mice, weighing 28–34 g and at 10–12 weeks of age were purchased from CLEA Japan, Inc. The mice were housed in an animal facility under 12/12 hour light/dark cycle, temperature of 24 ± 1°C, relative humidity of 55 ± 10% and negative atmospheric pressure. They were provided with mouse chow and filtered tap water ad libitum throughout the experiment. All animal experiments were performed according to the National Institute for Environmental Studies guidelines for animal welfare.
Particles Fine colloidal silica (Grade PL-20) was also supplied by the same company and had a primary particle size of 213 nm (Lot No. Y1Y001). The particles were suspended in water at a concentration of 239 mg/ml.
Experimental Design
Histopathology
Laminin Immunohistochemistry
Electron Microscopy
Characteristics of Fine and Ultrafine Colloidal Silica The scanning electron microscopic images of ultrafine (UFCSs) and fine (FCSs) colloidal silica are shown in Figure 1A and 1B. Both sizes of colloidal silica particles had a compact and spherical configuration. There was substantial difference in diameter between UFCSs (average size of 14 nm) and FCSs (average size of 213 nm). The surface area, which measured by Brunauer, Emmett and Teller (BET) method, was also much greater for UFCSs than FCSs particles, 194 and 13 m2/g, respectively. There was also a difference between UFCSs and FCSs in terms of metal composition, but both had very low levels (potassium, aluminium, magnesium <0.01 ppm; Iron <0.005 ppm; data were supplied by Fuso Chemical Co., Ltd., Japan). However, FCSs had a little more of sodium (0.10 ppm) and calcium (0.02 ppm) than UFCSs (sodium = 0.05 ppm and calcium <0.01 ppm).
Clinical and Gross Findings In FCSs treated animals, there were no exposure-related clinical signs in any observation time. Some mice in UFCSs treated animals showed a sign of dyspnea and died shortly after instillation (data are not shown). Grossly, instillation of UFCSs and FCSs caused congestion, edema and hemorrhage in lung. The degree of lung hemorrhage in UFCSs was more severe than FCSs treated animals at all observation times. In both UFCSs- and FCSs-treated animals, tiny pin-head sized white foci were scattered particularly in the pleural surface of lung lobes. At all time points, the hilar lymph nodes from UFCSs- and FCSs-treated animals were slightly enlarged compared to the control animals.
Light Microscopy
At 2 and 6 hours after instillation, the lesions in the lungs and hilar lymph nodes of both UFCSs- and FCSs-treated animals were similar to those seen in 30 minutes postexposure, but the lung lesions of UFCSs-treated animals were more severe than FCSs-treated animals. Attenuation of bronchiolar epithelial cells and accumulation of particle-laden alveolar macrophages (AMs) were observed (Figure 2C, 2D). Lungs of mice sacrificed at 6 hours after UFCSs instillation showed more severe bronchiolar epithelial cell desquamation than those of FCSs-treated animals. By 12 hours after instillation, UFCSs caused marked degeneration, attenuation and necrosis of bronchiolar epithelial cells, whereas FCSs caused mild degenerative effects (Figure 2E, 2F); both UFCSs- and FCSs-treated animals showed a significant influx of neutrophils scattering around the alveoli that contained particles. At 24 hours postexposure, UFCSs induced more extensive inflammatory changes than FCSs; marked increase of neutrophils sharply demarcated from the remaining normal alveoli were associated with these changes (Figure 2G, 2H). A number of nodular aggregate of neutrophils and particle-laden AMs were observed in some alveolar regions particularly in perivascular areas adjacent to the bronchioles. The nodular lesions consisted of clumps of free particles, some cell debris and particle-laden AMs, and neutrophils. Severe degeneration and necrosis of bronchiolar epithelial cells were still observed in the UFCSs-treated animals.
Laminin Immunohistochemistry
Electron Microscopy Morphology and Distribution of Particles in Lungs Two forms of UFCSs, singlet and aggregate forms, were observed in lung tissues. Almost all of singlet UFCSs were spherical, compact electron-dense particles with diameters approximately 10–14 nm. On the other hand, aggregates (diameter > 100 nm) of UFCSs were dominant that consisted of chains and clusters of UFCSs. The ultrastructural findings of FCSs also appeared as compact, spherical electron-dense particles with diameter approximately 213 nm, but all of FCSs remained separated and showed rarely the agglomerated pattern. Numerous free particles were observed on the bronchiolar epithelial cell surface and along the apical surface of the plasma membrane of alveoli in both UFCSs- and FCSs-treated animals even at 24 hours postexposure. Accumulation of particle-laden AMs was also found in the alveoli and bronchiolar lumens. These particle-laden AMs showed round or polygonal shapes with numerous lysosomes and phagolysosomes containing particles. Instilled particles were also observed in the cytoplasm of neutrophils that were presented around clumps of particles. Many singlet FCSs were seen in type II alveolar epithelial cell cytoplasm, in which some particles were occasionally observed in lamellar bodies. There were a few particles in the cytoplasm of type I alveolar epithelial cells. On the contrary, both singlet and small agglomerated UFCSs were incorporated by both types of alveolar epithelium.
Bronchiolar Lesions
Alveolar Lesions The ultrastructure of the lungs from UFCSs-treated animals demonstrated marked pathological changes compared to FCSs-treated animals. Type I alveolar epithelial cells had features of considerable damage particularly in the areas apposing to the clump of UFCSs particles. There was evidence of advanced injury to type I alveolar epithelial cells, with necrosis and desquamation leading to direct exposure of interstitial tissue to the alveolar space. Damage and dissociation of basement membranes were also found associated with type I alveolar epithelial cell erosion (Figure 4C). The capillary endothelium of the alveolar septa showed features of focal damage with increased numbers of vesicles in their cytoplasm. The vascular lumen displayed numerous neutrophilic granulocytes, which infiltrated through the capillary wall to the area with particle accumulation. The areas of lung parenchyma with neutrophil and alveolar macrophage accumulation showed remarkable damage of the alveolar wall structures.
Occupational exposure to crystalline silica dust is associated with an increased risk for pulmonary diseases such as silicosis. Numerous studies on the crystalline silica toxicity in experimental animals showed inflammatory effects and following pulmonary fibrosis and pulmonary dysfunction (Lugano et al., 1982; Reiser et al., 1982; Callis et al., 1985). While the pulmonary toxicity of crystalline silica is widely known, there is limited information regarding the lung toxicity by amorphous silica. Animal inhalation studies with synthetic amorphous silica showed reversible inflammation, granuloma formation and emphysema (McLaughlin et al., 1997; Merget et al., 2002). Occupational exposure to amorphous silica showed no any relevant potential to induce silicosis. Colloidal silica, one of synthetically made amorphous silica that became widely used in many industries and available for various applications, are known to be far less active in producing pulmonary damage when compared to crystalline silica (Warheit et al., 1991). Subchronic inhalation toxicity studies on colloidal silica reported that inhalation of Ludox colloidal silica produced dose-related pulmonary effects characterized by accumulations of dust-laden polymorphonuclear cells in alveolar ducts, concomitant with neutrophil infiltration and type II alveolar epithelial cell hyperplasia with small numbers of silicotic lesions. The severity and incidence of pulmonary lesions were reduced after a 3-month recovery period (Lee and Kelly, 1992). There are, however, limited data of the acute pulmonary effects after exposure to colloidal silica by intratracheal instillation. To understand acute inflammatory events in the lung following colloidal silica exposure, we exposed mice to UFCSs and FCSs and examined pulmonary changes by histology, immunohistochemistry and electron microscopy at intervals from 30 minutes to 24 hours postexposure. At 30 minutes and 2 hours postexposure, there was the evidence of severe degeneration and necrosis of bronchiolar epithelial cells with clumps of colloidal silica particles on epithelial cell surface, but no evidence of inflammatory reactions around the affected bronchioles. This suggested that colloidal silica has a direct toxic effect on lung epithelial cells and bronchiolar epithelial cells seem to be the first target for colloidal silica toxicity. It is generally accepted that the biological responses to amorphous silica are related to its surface properties. The composition and structure of particle surface functionalities such as hydrophilicity, impurities and specific surface functional group play an important role in the biological responses to silica. Silicon functionalities as well as traces of iron impurities on the silica surface are implicated in free radical release at the surface and in subsurface layers of particles (Vallyathan et al., 1988; Fubini et al., 1990). The specific surface silanol groups (SiOH) of silica are directly involved in both hemolysis (Pandurangi et al., 1990; Hemenway et al., 1993) and toxicity to alveolar cells in vitro (Mao et al., 1995; Fubini et al., 1999). It appears that the silanol presence is a prerequisite for the attachment of silica particles to the cell membrane and consequent cellular uptake by macrophages and neutrophils. This hypothesis is supported by the study showing that the silanol groups form hydrogen bonds with some sites on the cell membrane (Shi et al., 1989). Such hydrogen bonding could facilitate the process of phagocytosis. Furthermore, a specific binding of silanol group to the phosphate groups of DNA was reported (Mao et al., 1994). This close proximity between DNA and the active sites of the silica surface would enable the short-lived radicals to induce DNA damage (Saffiotti et al., 1994). Numerous experimental studies have shown that ultrafine particles have more ability to enhance lung injury than fine particles of the same chemical composition; the studies included a number of diverse materials such as cobalt, nickel, carbon black, and TiO2 (Baggs et al., 1997; Brown et al., 2000, Zhang et al., 2000, 2003). To our knowledge, there is no detailed pathological report on the pulmonary toxicity induced by different particle sizes of colloidal silica. In the present study, we compared acute pathological findings of lung between UFCSs- and FCSs-treated animals. The results showed that instillation of UFCSs induced more severe bronchiolar epithelial cell necrosis and purulent inflammation in alveoli than FCSs at 12 and 24 hour postexposure. Destruction of bronchiolar and alveolar basement membranes was detected as weak positivity of laminin immunolabellings; the immunopositivity in UFCSs treated animals was weaker than those in the FCSs-treated animals. These basement membrane damages were associated with particle accumulation. Concomitant ultrastructural studies confirmed more severe damage including dissociation of basement membranes and erosion of type I alveolar epithelial cell in UFCSs-treated animals than FCSs treated animals. Ultrafine particles have a much greater surface area than fine colloidal silica. Several plausible mechanisms have been proposed for the pathogenesis of the initial pulmonary injury following ultrafine particle exposure. The higher toxicity of ultrafine particles than fine particles may be related to the larger surface area per given mass. Higher surface area of particles can play a role as a carrier for co-pollutants such as gases and chemicals, specifically transition metals that could form a coat on the particle surfaces during their formation (Donaldson et al., 2001). Larger surface areas have also been associated with higher inflammatory responses, probably related to increased reactive oxygen species generation, independent of transition metal exposure. However, results of experimental studies with ultrafine particles composed of low-toxicity materials such as polystyrene have shown an increased inflammatory response with increased total surface area, without any contribution from other factors such as co-pollutants or transition metals. This suggests that surface area drives inflammation in short term and that ultrafine particles induce a greater changes because of the greater surface area they possess (Brown et al., 2001). In addition, it has also been suggested that high numbers of ultrafine particles in the alveolar region may overwhelm the capacity of alveolar macrophages to phagocytoze and allow interaction of particles with epithelial cells, resulting in decreased clearing efficiency of ultrafine particles from the alveoli and leading to epithelial cell injury (Renwick et al., 2001). In summary, this study showed detailed pathology of severe acute pulmonary inflammation and tissue injury induced by intratracheal instillation of colloidal silica; ultrafine colloidal silica particles induced more severe changes than fine colloidal silica particles. Larger surface area of particles might be an important factor in the induction of lung tissue injury.
The authors thank Ms. E. Kawahara for her excellent assistance in electron microscopy at Tottori University.
  CiteULike  Connotea  Del.icio.us  Digg  Reddit  Technorati What's this?
|
||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
 |
|
|
 |
 |
Sign In to gain access to subscriptions and/or personal tools.
TOP
Abstract
Introduction
